united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 0 kme miniature -105 c kme series the kme series capacitors are our standard general purpose capacitors. these radial lead capacitors are available in a wide range of voltage and capacitance ratings and have a rated lifetime of 1,000 hours with the rated ripple current applied. the kme series capacitors with working voltage of 100 or under also have a very low dc leakage current, .002cv or 2 a, whichever is greater after 2 minutes at 20 c. the kme series capacitors, except for those rated at 350-400 volts, were developed to withstand hcfc cleaning agents for five minutes by ultrasonic, vapor or immersion. this solvent proof design allows all circuit board components to be cleaned together, at the same time, without resorting to more expensive epoxy end-sealed capacitors. refer to the mini-glossary for recommended cleaning conditions. miniature general purpose solvent proof 105 c maximum temperature radial lead terminals. capacitance range: 0.1 to 15,000 f. voltage range: 6.3 to 400vdc. operating temperature range: 55 cto 105 c for 6.3 to 100v; 40 cto 105 c for 160 to 400v. leakage current: see specifications table for leakage current values at 20 c. standard capacitance tolerance: 20% nominal case size (d l): 5 11mm to 18 40mm. rated lifetime: 1,000 hours at 105 c with the rated ripple current applied. summary of specifications actual size
kme miniature -105 c united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 1 kme series kme specifications at 20 c where i = leakage current ( a ), c = nominal capacitance ( f ) and v = rated voltage ( v ) item operating temperature range 55 to 105 c for 6.3 to 100vdc; 40 to 105 c for 160 to 400vdc rated voltage range 6.3 to 400vdc capacitance range 0.1 to 15,000 f capacitance tolerance 20% ( m ) at 20 c, 120hz leakage current characteristics shelf life others the following specifications shall be satisfied when the capacitors are restored to 20 c after exposing them for 1,000 hours at 105 c without voltage applied. the rated voltage shall be applied to the capacitors for a minimum of 30 minutes, at least 24 hours and not more than 48 hours before the measurements. capacitance change: 20% of initial measured value tan (df) : 200% of initial specified value leakage current : initial specified value for 6.3 -100v : 500% of initial specified value for 160 - 400v satisfies characteristic w of jis c5141 load life the following specifications shall be satisfied when the capacitors are restored to 20 c after subjecting them to the dc rated voltage for 1,000 hours at 105 c with the rated ripple current applied. the sum of dc voltage and peak ac voltage must not exceed the full rated voltage of the capacitors. capacitance change: 20% of initial measured value tan (df) : 200% of initial specified value leakage current : initial specified value dc rated voltage 6.3 -100v 160 - 400v test time after 2 minutes after 1 minute after 5 minutes leakage current ( a) i 0.002cv or 2 a, whichever is greater. cv 1,000: i 0.1cv 40 cv > 1,000: i 0.04cv 100 cv 1,000: i 0.03cv 15 cv > 1,000: i 0.02cv 25 dissipation factor ( tan )at 20 c, 120hz when nominal capacitance exceeds 1,000 f, add 0.02 to the values above for each 1,000 f increase. rated voltage ( v ) tan (df) 6.3 0.22 10 0.19 16 0.16 25 0.14 35 0.12 50 0.10 63 0.09 100 0.08 160 - 250 0.20 350 - 400 0.24 350 - 400 6 6 50 2 3 rated voltage ( v ) z( 25 c) /z( 20 c) z( 40 c) /z( 20 c) 10 3 6 6.3 4 8 16 2 4 25 2 3 35 2 3 63 -100 2 3 160 - 250 3 4 low temperature characteristics at 120hz, impedance ( z ) ratio between the 25 c or 40 c value and 20 c value shall not exceed the values given below. ambient temperature ( c) 85 c 1.75 105 c 1.00 frequency (hz ) capacitance ( f) 3.3 f 4.7- 33 f 47-1000 f 2200 f 50hz 0.65 0.75 0.80 0.85 120hz 1.00 1.00 1.00 1.00 300hz 1.35 1.25 1.15 1.03 1khz 1.75 1.50 1.30 1.05 10khz 2.30 1.75 1.40 1.08 100khz 2.50 1.80 1.50 1.08 ripple current multipliers refer to section 4 of the mini-glossary for explanation of ripple current multipliers.
kme series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 2 kme miniature -105 c lead length: ll is standard. case code: see case sizes in tables. capacitance tolerance: m = 20% capacitance value: expressed in microfarads. the first two digits are significant figures, and the third digit indicates the number of zeros for capacitance of 100 f or more. r indicates the decimal point for capacitance less than 100 f (e.g. r22 = .22 f; 2r2 = 2.2 f; 22r = 22 f; 221 = 220 f; 222 = 2,200 f; 223 = 22,000 f). lead configuration: vb = radial lead. dc rated voltage: expressed in volts (e.g. 200 = 200wvdc). series name: indicates basic capacitor design. part numbering system for kme series when ordering, always specify complete catalog number for kme series. kme 200 vb 22r m 10x20 ll vb/radial lead unit: mm diagram of dimensions d 5 6.3 8 10, 12.5 16, 18 d ' max. d 0.5 d 0.5 d 0.5 d 0.5 d 0.5 l ' max. l 1.5 l 1.5 l 1.5 l 1.5 l 1.5 d 0.5 0.5 0.6 0.6 0.8 f 0.5 2.0 2.5 3.5 5.0 7.5 f f f f 15 min. pvc sleeve d ' d vent (except 5) l ' l d 5 ~ 8 12.5 ~ 18 10 4 min. gas escape end seal for all case diameters. for optional lead configurations and tape and ammo packaging, refer to the beginning of the miniature section. rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 33 kme6.3vb33rm5x11ll 5 11 11.05 54 47 kme6.3vb47rm5x11ll 5 11 7.759 65 100 kme6.3vb101m5x11ll 5 11 3.647 95 220 kme6.3vb221m6x11ll 6.3 11 1.658 160 330 kme6.3vb331m6x11ll 6.3 11 1.105 195 470 kme6.3vb471m8x11ll 8 11.5 0.776 270 1,000 kme6.3vb102m10x12ll 10 12.5 0.365 460 2,200 kme6.3vb222m12x20ll 12.5 20 0.181 810 3,300 kme6.3vb332m12x20ll 12.5 20 0.131 960 4,700 kme6.3vb472m16x25ll 16 25 0.099 1,330 6,800 kme6.3vb682m16x25ll 16 25 0.078 1,500 10,000 kme6.3vb103m16x31ll 16 31.5 0.066 1,765 15,000 kme6.3vb153m18x35ll 18 35.5 0.055 2,075 6.3 volts 8 volts surge * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve.
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 3 kme miniature -105 c kme series * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 22 kme10vb22rm5x11ll 5 11 14.315 49 33 kme10vb33rm5x11ll 5 11 9.543 60 47 kme10vb47rm5x11ll 5 11 6.701 70 100 kme10vb101m5x11ll 5 11 3.149 105 220 kme10vb221m6x11ll 6.3 11 1.431 175 330 kme10vb331m8x11ll 8 11.5 0.954 245 470 kme10vb471m8x11ll 8 11.5 0.67 290 1,000 kme10vb102m10x16ll 10 16 0.315 550 2,200 kme10vb222m12x20ll 12.5 20 0.158 860 3,300 kme10vb332m12x25ll 12.5 25 0.116 1,100 4,700 kme10vb472m16x25ll 16 25 0.088 1,400 6,800 kme10vb682m16x31ll 16 31.5 0.071 1,690 10,000 kme10vb103m18x35ll 18 35.5 0.061 1,950 10 volts 13 volts surge 10 kme16vb10rm5x11ll 5 11 26.52 35 22 kme16vb22rm5x11ll 5 11 12.055 54 33 kme16vb33rm5x11ll 5 11 8.036 64 47 kme16vb47rm5x11ll 5 11 5.643 77 100 kme16vb101m6x11ll 6.3 11 2.652 125 220 kme16vb221m8x11ll 8 11.5 1.205 215 330 kme16vb331m8x11ll 8 11.5 0.804 260 470 kme16vb471m10x12ll 10 12.5 0.564 370 1,000 kme16vb102m10x20ll 10 20 0.265 640 2,200 kme16vb222m12x25ll 12.5 25 0.136 1,000 3,300 kme16vb332m16x25ll 16 25 0.1 1,300 4,700 kme16vb472m16x31ll 16 31.5 0.078 1,600 6,800 kme16vb682m18x35ll 18 35.5 0.063 1,900 10,000 kme16vb103m18x40ll 18 40 0.061 2,060 16 volts 20 volts surge 4.7 kme25vb4r7m5x11ll 5 11 49.372 26 10 kme25vb10rm5x11ll 5 11 23.205 38 22 kme25vb22rm5x11ll 5 11 10.548 57 33 kme25vb33rm5x11ll 5 11 7.032 69 47 kme25vb47rm5x11ll 5 11 4.937 82 100 kme25vb101m6x11ll 6.3 11 2.321 135 220 kme25vb221m8x11ll 8 11.5 1.055 230 330 kme25vb331m10x12ll 10 12.5 0.703 335 470 kme25vb471m10x16ll 10 16 0.494 440 1,000 kme25vb102m12x20ll 12.5 20 0.232 770 2,200 kme25vb222m16x25ll 16 25 0.121 1,170 3,300 kme25vb332m16x31ll 16 31.5 0.09 1,460 4,700 kme25vb472m18x35ll 18 35.5 0.071 1,780 6,800 kme25vb682m18x40ll 18 40 0.059 1,950 25 volts 32 volts surge 4.7 kme35vb4r7m5x11ll 5 11 42.319 28 10 kme35vb10rm5x11ll 5 11 19.89 41 22 kme35vb22rm5x11ll 5 11 9.041 61 33 kme35vb33rm5x11ll 5 11 6.027 75 47 kme35vb47rm6x11ll 6.3 11 4.232 100 100 kme35vb101m8x11ll 8 11.5 1.989 170 220 kme35vb221m10x12ll 10 12.5 0.904 300 330 kme35vb331m10x16ll 10 16 0.603 400 470 kme35vb471m10x20ll 10 20 0.423 520 1,000 kme35vb102m12x25ll 12.5 25 0.199 920 2,200 kme35vb222m16x31ll 16 31.5 0.105 1,340 3,300 kme35vb332m18x35ll 18 35.5 0.08 1,650 4,700 kme35vb472m18x40ll 18 40 0.063 1,900 35 volts 44 volts surge
kme series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 4 kme miniature -105 c * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 0.1 kme50vbr10m5x11ll 5 11 1,657.5 1.3 0.22 kme50vbr22m5x11ll 5 11 753.409 2.9 0.33 kme50vbr33m5x11ll 5 11 502.273 4.4 0.47 kme50vbr47m5x11ll 5 11 352.66 7.0 1.0 kme50vb1r0m5x11ll 5 11 165.75 13 2.2 kme50vb2r2m5x11ll 5 11 75.341 20 3.3 kme50vb3r3m5x11ll 5 11 50.227 25 4.7 kme50vb4r7m5x11ll 5 11 35.266 30 10 kme50vb10rm5x11ll 5 11 16.575 46 22 kme50vb22rm5x11ll 5 11 7.534 68 33 kme50vb33rm6x11ll 6.3 11 5.023 90 47 kme50vb47rm6x11ll 6.3 11 3.527 110 100 kme50vb101m8x11ll 8 11.5 1.658 180 220 kme50vb221m10x16ll 10 16 0.753 345 330 kme50vb331m10x20ll 10 20 0.502 460 470 kme50vb471m12x20ll 12.5 20 0.353 610 1,000 kme50vb102m16x25ll 16 25 0.166 1,080 2,200 kme50vb222m18x35ll 18 35.5 0.09 1,530 50 volts 63 volts surge 4.7 kme63vb4r7m5x11ll 5 11 31.739 32 10 kme63vb10rm5x11ll 5 11 14.918 50 22 kme63vb22rm6x11ll 6.3 11 6.781 82 33 kme63vb33rm6x11ll 6.3 11 4.52 100 47 kme63vb47rm8x11ll 8 11.5 3.174 135 100 kme63vb101m10x12ll 10 12.5 1.492 225 220 kme63vb221m10x20ll 10 20 0.678 400 330 kme63vb331m12x20ll 12.5 20 0.452 540 470 kme63vb471m12x25ll 12.5 25 0.317 700 1,000 kme63vb102m16x31ll 16 31.5 0.149 1,210 63 volts 79 volts surge 0.1 kme100vbr10m5x11ll 5 11 1,326.0 2.6 0.22 kme100vbr22m5x11ll 5 11 602.727 5.8 0.33 kme100vbr33m5x11ll 5 11 401.818 7.8 0.47 kme100vbr47m5x11ll 5 11 282.128 10 1.0 kme100vb1r0m5x11ll 5 11 132.6 15 2.2 kme100vb2r2m5x11ll 5 11 60.273 23 3.3 kme100vb3r3m5x11ll 5 11 40.182 29 4.7 kme100vb4r7m5x11ll 5 11 28.213 34 10 kme100vb10rm6x11ll 6.3 11 13.26 56 22 kme100vb22rm8x11ll 8 11.5 6.027 96 33 kme100vb33rm10x12ll 10 12.5 4.018 140 47 kme100vb47rm10x16ll 10 16 2.821 180 100 kme100vb101m12x20ll 12.5 20 1.326 320 220 kme100vb221m16x25ll 16 25 0.603 570 330 kme100vb331m16x25ll 16 25 0.402 700 470 kme100vb471m16x31ll 16 31.5 0.282 880 100 volts 125 volts surge rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 0.47 kme160vbr47m6x11ll 6.3 11 705.319 9.0 1.0 kme160vb1r0m6x11ll 6.3 11 331.5 12 2.2 kme160vb2r2m6x11ll 6.3 11 150.682 19 3.3 kme160vb3r3m8x11ll 8 11.5 100.455 26 4.7 kme160vb4r7m8x11ll 8 11.5 70.532 31 10 kme160vb10rm10x16ll 10 16 33.15 59 22 kme160vb22rm10x20ll 10 20 15.068 95 33 kme160vb33rm12x20ll 12.5 20 10.045 125 47 kme160vb47rm12x25ll 12.5 25 7.053 165 100 kme160vb101m16x25ll 16 25 3.315 270 220 kme160vb221m18x35ll 18 35.5 1.507 450 160 volts 200 volts surge
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 5 kme series kme miniature -105 c * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 0.47 kme200vbr47m6x11ll 6.3 11 705.319 9.0 1.0 kme200vb1r0m6x11ll 6.3 11 331.5 12 2.2 kme200vb2r2m6x11ll 6.3 11 150.682 19 3.3 kme200vb3r3m8x11ll 8 11.5 100.455 26 4.7 kme200vb4r7m10x12ll 10 12.5 70.532 36 10 kme200vb10rm10x16ll 10 16 33.15 59 22 kme200vb22rm10x20ll 10 20 15.068 95 33 kme200vb33rm12x25ll 12.5 25 10.045 140 47 kme200vb47rm12x25ll 12.5 25 7.053 165 100 kme200vb101m16x31ll 16 31.5 3.315 285 220 kme200vb221m18x40ll 18 40 1.507 470 200 volts 250 volts surge 0.47 kme250vbr47m6x11ll 6.3 11 705.319 9.0 1.0 kme250vb1r0m6x11ll 6.3 11 331.5 12 2.2 kme250vb2r2m8x11ll 8 11.5 150.682 21 3.3 kme250vb3r3m10x12ll 10 12.5 100.455 30 4.7 kme250vb4r7m10x12ll 10 12.5 70.532 36 10 kme250vb10rm10x20ll 10 20 33.15 64 22 kme250vb22rm12x25ll 12.5 25 15.068 110 33 kme250vb33rm12x25ll 12.5 25 10.045 140 47 kme250vb47rm16x25ll 16 25 7.053 180 100 kme250vb101m18x35ll 18 35.5 3.315 310 250 volts 300 volts surge 0.47 kme350vbr47m8x11ll 8 11.5 846.383 10 1.0 kme350vb1r0m10x12ll 10 12.5 397.8 18 2.2 kme350vb2r2m10x16ll 10 16 180.818 30 3.3 kme350vb3r3m10x16ll 10 16 120.545 37 4.7 kme350vb4r7m10x20ll 10 20 84.638 48 10 kme350vb10rm12x20ll 12.5 20 39.78 79 22 kme350vb22rm16x20ll 16 20 18.082 130 33 kme350vb33rm16x25ll 16 25 12.055 175 47 kme350vb47rm16x35ll 16 35.5 8.464 230 100 kme350vb101m18x40ll 18 40 3.978 330 350 volts 400 volts surge 1.0 kme400vb1r0m10x12ll 10 12.5 397.8 18 2.2 kme400vb2r2m10x16ll 10 16 180.818 30 3.3 kme400vb3r3m10x20ll 10 20 120.545 40 4.7 kme400vb4r7m10x25ll 10 25 84.638 52 10 kme400vb10rm12x20ll 12.5 20 39.78 79 22 kme400vb22rm16x25ll 16 25 18.082 145 33 kme400vb33rm16x31ll 16 31.5 12.055 185 47 kme400vb47rm18x31ll 18 31.5 8.464 230 400 volts 450 volts surge not solvent proof not solvent proof rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 105 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead
kme series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 15 6 kme miniature -105 c 20 0 10 (at 20 c) 10 capacitance change (%) capacitance change (%) dissipation factor ( tan ) impedance (ohms) temperature characteristics temperature characteristics kme6.3vb102m10x12 kme16vb332m16x25 kme50vb1r0m5x11 kme50vb101m8x11 impedance frequency characteristics kme6.3vb102m10x12 kme16vb332m16x25 0.01 0.1 1 10 temperature ( c) dissipation factor ( tan ) temperature ( c) (at 20 c) impedance (ohms) impedance frequency characteristics kme50vb1r0m5x11 kme50vb101m8x11 40 20 0 80 105 60 40 20 40 20 0 80 105 60 40 20 55 40 20 0 20 40 60 80 105 20 0 10 10 55 40 20 0 20 40 60 80 105 0.01 0.1 1 10 10 1 0.1 0.01 100 1k 10k 100k 1m frequency (hz) 100 1k 10k 100k frequency (hz) 10k 1k 100 10 1 0.1 (at 120hz) (at 120hz)
|
